When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
This is a review of the Traeger Scout, purchased New in October 2018 and equipped with the "new" drip-pan and heat deflector. Essentially this specific unit, like many others, runs huge temperature swings. Per Traeger the unit is designed around a 13k BTU burner cup and comes with their Pro Controller with AGL. Frankly, in my judgement, the burner cup is too large for the cubic inch space of the grill area. In my experience, running Traeger pellets, the grill has functionally three temperature settings; 1) Off. This is self explanatory. Looks very pretty on a picnic table in the campground or on your patio table. 2) Hot and Smoky. Wide temperature swings, over-fueling, massive smoke followed by high temps. The controller gets into a "correction induced oscillation" of ever wider swings in temp potentially resulting in either Ler or Her shut downs. 3) Very, Very Hot. This is the high setting where it will run 500+ temps and gets the deflector/drip pan very hot even with the lid open. Burner sounds awesome in Open Lid Mode. Very Macho. Clearly this is a Grill and not a Smoker. The design has an over-engineered burner cup and a controller overwhelmed by the small area being heated. Traeger, I believe, understands the problem. For me, it's simplier to just find cheap, bad, low BTU pellets to decrease the output of the burner cup and then dial the P setting up to reduce the auger cycle....and then adjust my mental approach to how to use the grill accordingly (While I save up for a CampChef Pursuit 20.) I will keep my Scout and give it two stars because it's pretty and sounds so awesome in #3 mode, like a rocket trying to take off.
Brad Barrett at Grill Grates makes a fantastic product. Reverse searing 2″ steaks and chops (or thicker) works great on pellet smokers as you can get the internal temp up to 10-15 degrees below your desired finish temp, remove them and loosely wrap / cover in foil, crank up the smoker with the grates on to say, 400 degrees, and then sear off your protein getting great grill marks with little to no sticking at all. Huge fan of Grill Grates.

Just started shopping around for a pellet smoker. Am also going to need a new gas grill soon. Stopped in at the local BBQ supply store today and they showed me the Memphis Pro and said it would function well for both smoking and cooking steaks/burgers. Price point on that one is pretty high. Would any of the others reviewed above offer similar functionality? Do you have a recommendation of which will work well for both functions? I live in KS so kind of like the idea of sticking with the local guys from Yoder, but Fast Eddys in OK isn’t too far away either. Thanks.
The agency behind the advertising campaign for Squatty Potty really went for kitsch. To create buzz for the bathroom step stool, which positions consumers in a squatting stance to ease bowel movements, the team at digital marketing firm Harmon Brothers opted for a unicorn perched on a toilet while pooping glittery, rainbow-colored ice cream onto a conveyor belt of cones.

Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.

I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
The moment we found this as one of our most desired articles, we had to conduct extensive research on what a pellet grill is. With that said, if you are new to the pellet grill industry and want to know what it is, here we go! Pellet grills are often considered, ‘pellet smokers’, due to the construction quality and design. The reason is that pellet grills combine different cooking elements such as charcoal, gas grills, and a conventional kitchen oven. Now, they are fueled by wood pellets, hence the name. With that said, pellet grills can smoke, cook, and grill all in one simple mechanism and design. With an electronic control panel, an individual can control the wood pellets that fuel the fire to regulate airflow and maintain the proper cooking temperature. Did you get that? We hope so because it is time we share with you the criteria to evaluate the best pellet grills.
The Dyna-Glo Signature Series DGSS681VCS-D Heavy-Duty Vertical Charcoal The Dyna-Glo Signature Series DGSS681VCS-D Heavy-Duty Vertical Charcoal Smoker will satisfy your outdoor cooking needs. This Heavy-Duty Vertical Charcoal Smoker features a porcelain enameled steel charcoal chamber which keeps briquettes tightly packed for improved burn efficiency. The removable high capacity ash pan handles large amounts of ash facilitating hours of ...  More + Product Details Close
Editor's Note: If you're looking to upgrade your backyard cooking setup this summer, you're probably in need of a little advice. We're longtime admirers of the folks behind AmazingRibs.com, the site dedicated to unraveling the science of barbecue and grilling. Please welcome back Max Good, the only person in the world whose full-time job is testing, rating, and reviewing grills and smokers. The database he maintains includes over 500 grills and smokers, ranging in price from $30 to $50,000. When it comes to barbecue equipment, nobody knows it better.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.

The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.

Convert your stove into a powerful barbecue grill. Convert your stove into a powerful barbecue grill. This barbecue grill box is sure to win you over to Camp Chef's savory outdoor flavor. Features a reverse-louvered plate to vaporize grease drippings while distributing heat evenly over the cooking surface to create a more flavorful cooking experience. Cast iron grates ...  More + Product Details Close

Cleaning and Maintenance: Keeping the grill clean is critical if you need to get the most out of the unit. Old debris can influence the viability of the unit thus normal cleaning is vital. In addition, while moving it around, take alert not to thump it since it accompanies little legs which can without much of a stretch tip over the unit when thumped.
All orders will be shipped by FedEx standard ground. Oversized or overweight orders may be shipped using a different freight carrier and may require scheduling for delivery.  For those orders we recommend you call us directly for a shipping quote.  For Alaska & Hawaii orders please e-mail us for a shipping quote [email protected] Presently, we do not offer international shipping and are unable to drop ship to P.O. Boxes, APO, FPO or other Military Addresses. We require all "ship-to addresses" to be valid street addresses.
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.

This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.
For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.

I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods! 🙂
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.
Each of the alternatives to the Traeger Pro we’ve reviewed above is an excellent choice for an affordable pellet smoker. We think the Z Grills Master 700D is worth every penny and competes with the Traeger for even less money. We highly recommend you check it out. It has an even larger grill area, a larger hopper, burns just as consistently, and produces some perfectly smoked and grilled meats.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
Yes, no one likes to read the instruction manual. But there are many advantages of learning the specifics of your grill and reading the manual is key. Generally, you should not use water to clean your pellet smoker, so keep your hose pipe far away. These smokers have digital controllers, a motorized auger, a fan and an igniter rod for the fire pot. These parts will get destroyed if they come into contact with water. You should gently dry scrub the dirt off these parts, making sure not to disassemble any parts. Cleaning the thermostat will also prove to be essential; otherwise, it may read internal temperatures inaccurately.
We did return the Traeger to Costco for a full refund. It's not that Traeger has poor customer service; they don't have any customer service. We brought a Bradley Smoker, an upright design, and it has performed much better than the Traeger. The Bradley also takes up much less space and we've placed it on a dolly so it can be rolled around. Overall, a much better solution.
The completed transaction enhances Vista Outdoor's position within one of the camping market's most attractive categories, complementing its already broad portfolio of 50 brands in shooting sports and outdoor recreation. Wholesale dollar sales in the camping category grew at a 6% Compound Annual Growth Rate (CAGR) from 2010 to 2015 (source: Sports & Fitness Industry Association). Camp Chef's sales growth has been fueled by a strong product development pipeline and user-friendly products.
At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.
The first thing we have to understand is the anatomy of a pellet smoker. Check the related section on this page to get the idea. Once we know which part goes where, the bigger battle will be won. Next, we’re going to have to be able to analyze the problem if we are to solve it. What seems to be the issue? Are the pellets not lighting up? Are the pellets getting stuck and not working properly? Weird noises coming out from the hopper? Are foods not cooking well? Let’s take a look at these problems and how to solve them:

The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
Hey Eric! Man, thank you for the kind words. While I don’t post every day, I do try to make what I share with you guys as informative as possible. To that end, your words mean a lot. Now, the pellet release option is a great feature to have on any pellet smoker. In cases where you don’t have one, I suggest using a small shop vac you use just for pellet removal. Works great. But the quick release chute option saves a ton of time and effort for sure. Not what I’d call a deal breaker if a pellet smoker you like doesn’t have one. However, I’d like to see it become standard on pellet smokers for sure!
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?

On May 1, 2017, the Grill God made his debut. Bedecked in a toga with a laurel wreath atop his wise-looking head and armed with a tool belt crammed with barbecue seasoning and dangling tongs slung jauntily across his hips, the carnivore’s deity appears. As lightning bolts and heavenly rays burst through the grimy grates of a wretched-looking grill, the master of Southern barbecue begins preaching about the divine benefits of a pellet smoker to a misguided suburban dad destined for mediocre cookouts unless he changes his sinful ways of conventional meat preparation.

Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.
Most pellet smokers have a flat drip plate under the cooking grate that diffuses heat and catches grease and gunk. Louisiana uses a curved "Arched Flavor Guard" that mirrors the shape of the lid. The company claims that this design presents a larger surface for meat drippings to sizzle and enhance flavor. The Flavor Guard also has a section over the fire pot that can slide out of the way to expose large, slotted openings, which allow meats to sear over open flame.
Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/
The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
The digital interface, which changes the grill temperature by adjusting how quickly the pellets are fed into the fire pit, makes cooking virtually foolproof. I used the display to set the temperature, and the grill beeped when it was ready to go. Once my meat was on the grill, I adjusted the timer to alert me when I needed to flip the food, and set the thermometer to check the meat’s internal temperature, which flashes on the display. The Ranger cooked my chicken in about the same time as my propane grill, but the temperature control meant I spent less time worrying about over- or undercooking. In all, the Ranger delivered the superior taste of grilling with the ease of oven cooking.
-Warranty-(Forgive my soapbox here, folks.) I'd give it 5 stars if Camp Chef would give it a real warranty. One year is pathetic and WAY below the industry standard. Camp Chef, I know you are reading this because you guys are too excited about your great new product to not pay attention to feedback like this. Nut up and stand behind your awesome product. Why would anybody buy a product from an industry newcomer with no track record when you yourself are only willing to stand behind it for 1 lousy year?... Especially when the "industry leader" will guarantee their product for 3 years?!?! You are communicating that you have 1/3rd the amount of trust in your product that Traeger does. That's terrible! You should exceed what they are offering just to make the point in the industry! At a minimum, you should at least match their warranty just so it doesn't become a stumbling block to potential customers. Look, you basically took the lil tex and said "ok boys, so how can we make this better?!?" You did that! You totally knocked it out the park! Why cheap out with the warranty?!? As a customer, it makes me nervous that you know something I don't.
UPDATE 8/27 - This grill is still performing flawlessly. No error messages, maintains temperatures. I have made homeade pizzas and strombolis on a pizza stone and it actually makes them better than in the oven. Its like a restaurant wood fired pizza. I made a pork butt, beef brisket, bacon wrapped scallops....it just simply cooks everything well. Love my Pit Boss !!
In fact, 80 to 85% of pellet smokers in the USA are Traegers. The consensus is that they are reasonably well built, though some buyers complain that quality has dropped since manufacturing moved to China. But of course we hear more complaints—as well as more praise—about Traegers, since eight out of 10 pellet smoker owners have one. Traeger can be found in many national chains, like Cabela's and Costco. It's not unusual to find special deals on this popular product line, so keep your eyes open.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time

Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
×