After looking at a lot of pellets smoker grill reviews, it is easy to see that this is a pretty decent model. It is just so functional. So if you are looking to purchase something that is more than a pellet smoker, this is the product for you. Make sure to follow the instructions carefully when assembling it and be sure to gauge cooking time since this is a fast one.

It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.

Something you may not have read in other Pellet smoker reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average. So, if you want to do a pellet smoker cook using 100 percent cherry wood pellets, you’re going to use more fuel than you would with a cherry/hardwood blend, and it’s going to cost you more as well on average.
Minor problems (Product): 1. Main grill rack does not fit snugly, leaving the rack to half almost a half an inch in all directions to move. (not so much a problem when cooking but it does move) 2. Wind is a major factor making it difficult for this to get up to heat and stay there. 3. It rarely comes to the temperature I set it for, and usually is about 10-15 degrees below, with trying all of the different possible adjustment settings.
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.
You have some solid reviews out there. I have been in pursuit of getting exactly what I want for about 25 years now LOL. Started with a Weber Kettle cooked some great meals on it and made that tasted more like eating a chunk of lump coal 🙁 Over the years I have built a couple 55 gal barrel smokers they were challenging to hold the temp, an old Kenmore stove oven into a propane starter wood smoke unit, a monster 24″ pipeline pipe 5′ long and a warming oven, a 40″ stainless grill made from an industrial engine catalyst that I could direct and indirect cook on and a few other small grills. Working in the oil & gas business and having poor welding skills with a good welding machine in the garage made for some great experiences. Most generally have cooked for 2 to 4 people but have fed up to 70 a time or two.
I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.

I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
If you’ve used a pellet grill in the past, you’ll be familiar with its combination of wood smoke flavor and easy, digital temperature control. What the Timberline 850 adds are higher temperatures—up to 500 degrees—the ability to lower the main grill rack closer to the fire for better searing, double-walled construction that better insulates the grill from outside temperatures, and wireless connectivity that allows you to monitor grill and probe temperatures from your smartphone. Those might sound like small changes, but together they make for a sleeker grill with an appreciable increase in capability and convenience. Being able to watch the internal temperature of a piece of meat remotely is particularly useful and has helped ensure that not a single thing I’ve cooked on the Timberline has been overdone. 

Traeger wood pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger’s wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.

I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.
Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~
Something you may not have read in other Pellet grill reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average.
After looking at a lot of pellets smoker grill reviews, it is easy to see that this is a pretty decent model. It is just so functional. So if you are looking to purchase something that is more than a pellet smoker, this is the product for you. Make sure to follow the instructions carefully when assembling it and be sure to gauge cooking time since this is a fast one.
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
Fast forward to today.   Finally got my new Traeger running again.  Had an issue with the smoker temperature.   So I called the toll free Traeger customer service line.   Low and behold, who answers my call at Traeger customer service?  Frank!   He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!"   Nice guy!   Dude, being a smart aleck didn't exactly earn you any points.  You should be ashamed of your self!
Cleaning up after grilling is every cook’s dreaded part of the process, but this pellet grill simplifies that. Its warming rack comes with a patented ash-catcher system, the Ash Can Cleanout System, that allows for an easier cleanup of the unit. Additionally, it also features a grease drip disposal system that comes with a bucket. You won’t have to waste precious time cleaning up afterward!
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
Portability Even if you never take your pellet grill on a road trip, you might want to move it from one side of the yard to the other when you’re having a party, or move it out of the way when you’re not using it. While some pellet grills are light enough to pick up and carry, wheels make the job easier. Of course, if you have a permanent spot for your grill, portability is less of a consideration.
×